|2,4-TOLUENE DIISOCYANATE||ICSC: 0339 (May 2018)|
| CAS #: 584-84-9
| UN #: 2078
|EC Number: 209-544-5
|ACUTE HAZARDS||PREVENTION||FIRE FIGHTING|
|FIRE & EXPLOSION||Combustible. Gives off irritating or toxic fumes (or gases) in a fire. Risk of fire and explosion as a result of decomposition when heated.||NO open flames. NO contact with water.||Use powder, carbon dioxide, water in large amounts. In case of fire: keep drums, etc., cool by spraying with water. NO direct contact with water. Combat fire from a sheltered position.|
|AVOID ALL CONTACT! IN ALL CASES CONSULT A DOCTOR!|
|Inhalation||Sore throat. Cough. Headache. Nausea. Vomiting. Shortness of breath. Laboured breathing. Symptoms may be delayed. See Notes.||Use local exhaust. Use breathing protection.||Fresh air, rest. Half-upright position. Artificial respiration may be needed. Refer immediately for medical attention.|
|Skin||Redness. Blisters. Pain.||Protective gloves. Protective clothing.||Remove contaminated clothes. Rinse and then wash skin with water and soap. Refer for medical attention .|
|Eyes||Redness. Pain. Blurred vision.||Wear face shield or eye protection in combination with breathing protection.||First rinse with plenty of water for several minutes (remove contact lenses if easily possible), then refer for medical attention.|
|Ingestion||See Inhalation.||Do not eat, drink, or smoke during work.||Rinse mouth. Refer immediately for medical attention.|
|SPILLAGE DISPOSAL||CLASSIFICATION & LABELLING|
|Evacuate danger area! Consult an expert! Special emergency response required.||
According to UN GHS Criteria
DANGERFatal if inhaled
Causes skin irritation
Causes serious eye irritation
May cause respiratory irritation
May cause allergy or asthma symptoms or breathing difficulties if inhaled
May cause an allergic skin reaction
Suspected of causing cancer
Harmful to aquatic life with long lasting effects
|Separated from food and feedstuffs. Separated from : see Chemical Dangers. Store between 20°C and 25°C. Dry. Keep in a well-ventilated room. Store in an area without drain or sewer access. Refer to the manufacturer's instructions for proper storage conditions.|
|Do not transport with food and feedstuffs.|
|2,4-TOLUENE DIISOCYANATE||ICSC: 0339|
|PHYSICAL & CHEMICAL INFORMATION|
Physical State; Appearance
Formula: C9H6N2O2 / CH3C6H3(NCO)2
|EXPOSURE & HEALTH EFFECTS|
Routes of exposure
Effects of short-term exposure
Effects of long-term or repeated exposure
|OCCUPATIONAL EXPOSURE LIMITS|
TLV: (inhalable fraction and vapour): 0.001 ppm as TWA; 0.005 ppm as STEL; (skin); (DSEN); (RSEN); A3 (confirmed animal carcinogen with unknown relevance to humans); BEI issued.
MAK: (vapour and aerosol): 0.007 mg/m3, 0.001 ppm; peak limitation category: I(1); (momentary value that should not be exceeded): 0.035 mg/m3, 0.005 ppm; pregnancy risk group: C; sensitization of respiratory tract and skin (SAH)
|The substance is harmful to aquatic organisms. The substance may cause long-term effects in the aquatic environment.|
|Technical toluene diisocyanate is either 100% 2,4- or a mixture of 2,4- and 2,6-isomers. TDI is a common name. CAS number of the mixture is 26471-62-5.
Depending on the degree of exposure, periodic medical examination is suggested.
The symptoms of asthma often do not become manifest until a few hours have passed and they are aggravated by physical effort. Rest and medical observation are therefore essential.
Anyone who has shown symptoms of asthma due to this substance should avoid all further contact.
The odour warning when the exposure limit value is exceeded is insufficient.
Symbol: T+; R: 26-36/37/38-40-42/43-52/53; S: (1/2)-23-36/37-45-61; Note: C
|All rights reserved. The published material is being distributed without warranty of any kind, either expressed or implied. Neither ILO nor WHO nor the European Commission shall be responsible for the interpretation and use of the information contained in this material.|